Every recall we track for KTM North America, Inc. — 16 in all — plus the complaints and injury reports the public filed about them.
KTM recalls 2022-2024 Husqvarna FE 350S motorcycles with rear brake caliper cracks that could reduce braking and cause crashes. Owners must have calipers replaced by dealers by September 2026.
KTM recalls 2022-2024 RC 390 motorcycles due to water entering throttle control causing loss of drive power. Owners must contact KTM for free replacement by April 30, 2026.
KTM recalls 2025 390 Adventure R motorcycles due to side stand spring failure causing falls that may shut off ignition and increase crash risk. Owners must secure side stand before riding until repair.
KTM recalls 2024 Husqvarna Svartpilen 401 motorcycles with potential fuel leaks that could cause fire. Owners must have fuel cap gasket replaced free by dealers.
KTM recalls 2022-2024 Husqvarna FE 350s and FE 501s for potential front brake caliper cracks that could increase crash risk. Owners receive free brake caliper replacements.
KTM recalls 2020-2022 Super Duke R motorcycles due to wiring harness issues that may cause engine stalls and crash risks. Owners must have dealers inspect and repair the electrical system free of charge.
KTM recalls 2019-2023 Husqvarna 701 Enduro LR motorcycles with TKC80 tires due to tread cracks risking separation and crashes. Owners must replace tires free of charge.
Complaints and injury reports the public filed with federal agencies, linked to KTM North America, Inc.’s recalls — unedited excerpts.
Numerous 2024 models have been delivered with improperly greased front wheel bearings. There are many complaints about this reported on line. On delivery my motorcycle exhibited a grinding sound coming from the front wheel. At the 625 mile dealer service the g…
While commuting to work on 5/26/26, around 5:30 am, I felt my vehicle decelerate, and the throttle became unresponsive. I shifted into neutral and coasted for a little while, working the throttle from limit to limit to feel its responsiveness. After a few cycl…
I purchased the motorcycle March 27th, 2026 and was told that I would receive it within a week. Then had to call KTM on April 15, 2026 and was told by a representative that it would be another week to receive the part. The following week came by and was told i…
in certain comditions when using the turn signal a yellow "turn light will pop up on the screen and the blinker fail to function properly. if that pops up all blinkers stop working
Vehicle frequently stalls or engine stops suddenly. Engine will "knock" and suddenly stall when engaging the clutch while providing throttle to begin riding. It will stall when engaging the clutch to downshift into lower gears while coming to a stop. This has …
The contact owns a 2025 KTM 390 Adventure R. The contact stated that while riding the motorcycle on several occasions at various speeds in weather under 60 degrees, the left or right turn signals were activated but failed to operate as intended. Additionally, …
The contact owns a 2025 KTM 390 Adventure R. The contact stated that while riding at approximately 30 MPH, the kickstand extended into the parking stance. The contact stated that the motorcycle shut off as a default and lost power after the kickstand unfolded.…
KTM has not yet provided a schedule for recall notification.
