New Flyer XT60 problems & complaints
What New Flyer XT60 owners have reported to NHTSA, the service bulletins the manufacturer sent dealers, and any federal defect investigations, by model year. See New Flyer XT60 safety recalls or check your VIN.
- Owner complaints
- 0
- Service bulletins (TSBs)
- 28+
- Crashes / fires reported
- 0 / 0
- Defect investigations
- 0
Complaints by model year
Complaints owners filed with NHTSA, by the model year of the vehicle. A high count can also mean a popular year, so compare it with how many were sold.
| Year | Complaints | Crashes | Fires | Injured | Deaths | TSBs |
|---|---|---|---|---|---|---|
| 2020 | 0 | 0 | 0 | 0 | 0 | 3 |
| 2019 | 0 | 0 | 0 | 0 | 0 | 3 |
| 2018 | 0 | 0 | 0 | 0 | 0 | 4 |
| 2017 | 0 | 0 | 0 | 0 | 0 | 9 |
| 2016 | 0 | 0 | 0 | 0 | 0 | 14 |
| 2015 | 0 | 0 | 0 | 0 | 0 | 25 |
| 2014 | 0 | 0 | 0 | 0 | 0 | 28 |
Technical service bulletins (TSBs)
Repair instructions and other communications the manufacturer sent dealers about known issues. A TSB is not a recall, and the repair is usually free only while the car is under warranty; ask your dealer for the bulletin number.
- ITS61267
Instructions to replace current k-member with an upgraded casting design.
- TSIB 22-13 Rev B
Service bulletin increasing the torque value of a joint in a double-tilt steering column spline shaft.
- ITS59266
Technical Instruction describing how to mechanically fasten the Engergy Guide System (EGS) support brackets to the existing upper bulkhead structure at the articulation joint.
- SMB186
Service Manual Bulletin providing revised, corrected or additional information for the Preventive Maintenance on buses specifically equipped with a Powerex direct drive air compressor.
- SMB188
Service Manual Bulletin provides revised information for the Preventive Maintenance on specifically equipped vehicles with the Powerex belt driven air compressor.
- SMB187
Service Manual Bulletin which stresses the need for safety when performing maintenance on the high voltage systems on your New Flyer vehicle.
- SMB-182
This Service Manual Bulletin Identifies a New Requirement for Bolt Replacement in the Artic Joint Support Frame Installed on your New Flyer Vehicle.
- SMB178
This Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
- PMB049
This Parts Manual Bulletin provides new part number information for the moveable arm kit for the Kongsberg brake and accelerator assembly on specifically equipped vehicles.
- SMB176
This Service Manual Bulletin provides new information on how to check for proper chain tension, as measured by the chain deflection, while performing the ramp mechanism initial adjustments. This bulletin only applies to vehicles with New Flyer designed ramps.
- ITS6467
This Maintenance Instruction Describes How to Add Re-enforcement Brackets to the Existing Air Accessory Tank Mounting Bracket.
- SMB173
This bulletin provides PM inspection requirements for the K-menber on the fuel tank support structure
Source: NHTSA Office of Defects Investigation public data (complaints, manufacturer communications, investigations), model years 2010 and later. Had a safety problem? Report it to NHTSA.
Questions
What are the most common New Flyer XT60 problems?
0 owner complaints are on record with NHTSA.
Is a complaint or a TSB the same as a recall?
No. A complaint is an unverified report from an owner. A technical service bulletin (TSB) is the manufacturer telling dealers how to fix a known issue; it is not a safety recall and is usually covered only under warranty. A recall is a formal safety action, and its repair is free.
How do I report a problem with my New Flyer XT60?
File a vehicle safety complaint at NHTSA.gov. NHTSA reads every report, and patterns of complaints are what open defect investigations and, eventually, recalls.