What MAZDA MAZDA6 owners have reported to NHTSA, the service bulletins the manufacturer sent dealers, and any federal defect investigations, by model year. See MAZDA MAZDA6 safety recalls or check your VIN.
Complaints owners filed with NHTSA, by the model year of the vehicle. A high count can also mean a popular year, so compare it with how many were sold.
| Year | Complaints | Crashes | Fires | Injured | Deaths | TSBs |
|---|---|---|---|---|---|---|
| 2021 | 17 | 0 | 0 | 0 | 0 | 301 |
| 2020 | 2 | 0 | 0 | 0 | 0 | 364 |
| 2019 | 6 | 0 | 0 | 0 | 0 | 419 |
| 2018 | 58 | 1 | 1 | 1 | 0 | 549 |
| 2017 | 60 | 1 | 0 | 1 | 0 | 516 |
| 2016 | 77 | 9 | 0 | 8 | 0 | 670 |
| 2015 | 60 | 6 | 0 | 2 | 0 | 609 |
| 2014 | 137 | 14 | 0 | 7 | 0 | 757 |
| 2013 | 23 | 1 | 0 | 2 | 0 | 238 |
| 2012 | 99 | 5 | 2 | 6 | 0 | 247 |
| 2011 | 135 | 8 | 1 | 6 | 0 | 248 |
| 2010 | 225 | 5 | 2 | 2 | 0 | 250 |
The vehicle systems named most often in MAZDA MAZDA6 complaints (one complaint can name several).
In the owners’ own words, as filed with NHTSA. Unverified reports; NHTSA removes personal details before publishing.
Crossmember is rusted out and car is undriveable. There is a recall on the crossmember front subframe
The contact owns a 2013 Mazda Mazda6. The contact received notification of NHTSA Campaign Number: 18V018000 (Air Bags). The dealer confirmed the recall but was unable to perform the recall repair. The dealer informed the contact that there was no crash pad that was better. The dealer suggested that the vehicle be sold or not driven. The manufacturer was contacted and advised the contact to work with the dealer. The mileage was approximately 137,450.
The contact owns a 2016 Mazda Mazda6. The contact stated that while driving at an undisclosed speed, a burning odor was noticed inside the vehicle. No warning lights illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the clutch disc kit had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was filed. The failure mileage was approximately 125,166.
Have had 3 seats replaced under warranty by Graco and was told to make a report with you. The rigid latch anchors on two have been faulty after 2 months. The second one got stuck in the installed base and pulling the release button did nothing. The rigid latch on the first got stuck in the open position. The second they would move independently of each other and not lock in. The third is starting to have the same issue with getting stuck in the base. These have all happened within two months of normal use.
Fuel pump is leaking, just as all the other 2018-2020 fuel pumps but mine doesnât qualify for the recall.
The car only has 70k miles on it. The engine started smoking under the hood. Immediately stopped to look. There was oil leaking but I could not see from where. I took it across the street to the Toyota dealership and had them look at it. They explained to me that there was a crack in the cylinder head and oil was leaking everywhere. Potentially causing a fire or even an explosion. The old was leaking all over the exhaust manifold and engine. I had my 2 toddlers in the car not long before this happened. This is extremely unacceptable. Currently Mazda is saying it will be 7200 to replace the engine and that cost is on me. I think that is absolutely absurd being there are only 70k miles on the …
Got error message that said "Forward Smart City Brake Support Malfunction" slso fot "smart brake malfunction" while driving. The ac stopped, the car speedometer kept going from 50 to zero. The car died and couldn't open doors, windows. Lost steering while driving. We were able to get off road and restart and fine for 2 weeks. While at still light tonight, the car turned off. Windows were up, couldn't open door, emergency blinkers would not come on. This is very dangerous.
The infotainment touchscreen display in my 2017 Mazda 6 is experiencing a "ghost touch" defect, where the screen registers inputs without being touched. The defective touchscreen is available for inspection upon request. While driving, the system randomly changes settings, switches menus, activates functions, and changes audio or navigation screens without driver input. This creates a safety hazard because it distracts the driver and requires attention to be diverted from the road to address the unexpected screen activity. The issue occurs repeatedly and can happen at any time while the vehicle is in motion. The condition has been reported numerous times to an authorized Mazda dealership, …
Repair instructions and other communications the manufacturer sent dealers about known issues. A TSB is not a recall, and the repair is usually free only while the car is under warranty; ask your dealer for the bulletin number.
DESCRIPTION If you encounter any type of electrical concern (e.g, dead battery, engine no start, DTC(s) stored...), interview the customer before proceeding with normal MGSS diagnosis by asking if any aftermarket devices have been installed. Aftermarket devices may be the cause of the electrical concern. Below are a few examples of unusual electrical concerns caused by aftermarket devices. Examples: 1. Devices connected to the DLC-2 (battery discharge/DTC stored) 2. Devices plugged into the 12V outlet 3. GPS tracking device (engine no start/battery discharge) 4. Dash cam (DTC stored) 5. Non-ce
Product Quality Information (PQI) DESCRIPTION Service Information MT-041/12 is no longer valid. It has been unpublished and superseded by the Field Quality Information Report (FQIR) reporting system.
This bulletin supersedes the previously issued bulletin(s) listed below. The changes are noted in Red text. 09-042/04 12/10/04 DESCRIPTION Some vehicles may exhibit inoperative electric rear window defroster grid lines, integral antenna concerns causing radio reception issues or terminal tabs pulled from the rear window glass. Follow the diagnostic and repair procedures included in this service information to inspect and service rear defroster grid lines, integral antenna concerns or broken terminal tabs.
This SA supersedes the previously issued SA(s) listed below. The changes are noted in Red. SA-061/25 12/17/25 DESCRIPTION If you encounter any type of electrical concern (e.g, dead battery, engine no start, DTC(s) stored...), interview the customer before proceeding with normal MGSS diagnosis by asking if any aftermarket devices have been installed. Aftermarket devices may be the cause of the electrical concern. Below are a few examples of unusual electrical concerns caused by aftermarket devices. Examples: 1. Devices connected to the DLC-2 (battery discharge/DTC stored) 2. Devices plugged int
This bulletin supersedes the previously issued bulletin(s) listed below. The changes are noted in Red. 09-012/21 12/13/21, 06/10/21 and 04/27/21 DESCRIPTION Some customers may experience all of following symptoms: The door lock/unlock operation will not work using the remote transmitter button. 1. The door lock/unlock operation will not work using the door lock/release touch sensor. 2. The engine will not start using the ignition switch. 3. The transmitter operates by itself. 4. The key battery drains faster than usual. 5. Symptoms 1-3: This may be caused when excess load is applied to the rem
This SA supersedes the previously issued bulletin(s) listed below. The changes are noted below in Red. SA-027/26 04/16/26 DESCRIPTION The Mazda DCA-8000 is required for all warranty battery testing. If the Mazda DCA-8000 is not used, incorrect battery testing may result in unnecessary battery replacement. Use the following test procedures in this Service Bulletin to test Mazda vehicle batteries and to generate a Warranty Code. NOTE: A Warranty Code is required for warranty claim submission Battery Identification (Mazda batteries have 2 rating types) 1. JIS (Japanese Industrial Standard): JIS c
This bulletin supersedes the previously issued bulletin(s) listed below. The changes are noted in Red. 01-008/23 06/05/23 Some vehicles may exhibit rattling noises from the engine compartment and oil leakage from the drive belt auto tensioner. This may be caused by insufficient sealing at the drive belt auto tensioner damper when the auto tensioner fully operates under both high ambient temperature and high load conditions. To eliminate this concern, the shape of the drive belt auto tensioner damper has been changed. REPAIR PROCEDURE If the tensioner is found to be "No Good" after completing
DESCRIPTION Some vehicles may require the replacement of a damaged VIN plate or vehicle certification label. To obtain a replacement VIN plate (bulkhead-mounted and visible through the lower-left area of the windshield), contact DAG (Dealer Assistance Group) using VIN Plate Request Form available on One Mazda. To obtain a replacement vehicle certification label (located on the Bôpillar or front door), contact your assigned DSM (District Service Manager) to place the order. If DSM contact information is not available, refer to the Dealer & Field Contact Directory.
Valve Stem Seals Class Action Settlement Program for Excessive Oil Consumption and Oil Consumption Powertrain Warranty Extension Special Service Program SSPD5. Updated April 28, 2026 â Related oil part number for warranty claims is now 0000-77-5W30-QT (engine oil) as the 5555 warranty part number has been removed. As a reminder, all coverage reverts back to the original extension of 7 years or 84,000 miles whichever comes first. WARRANTY EXTENSION If you have any questions regarding this campaign, please read the Mazda Dealer FAQâs available in MGSS under this campaign before contacting De
This Service Alert supersedes the previously issued SA listed below: The changes are noted in Red. SA-011/24 02/12/24, 06/06/24, 07/29/24 DESCRIPTION Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manual. Services performed outside of Mazda's factory scheduled maintenance are not recommended. These services are unnecessary and create unneeded expenses for your customers. SCHEDULED MAINTENANCE Refer to the ap
This Service Alert supersedes the previously issued M-Tip(s) listed below. The changes are noted in Red text. MT-002/19 09/30/19 and 12/19/19 DESCRIPTION If an engine assembly is replaced after a catastrophic internal mechanical failure, clean the intake manifold internally before installing a replacement engine assembly. If the intake manifold is not cleaned properly, the replacement engine may fail prematurely. Metallic debris from the old engine (with catastrophic internal mechanical failure) may rest inside the intake manifold. When the new engine assembly is installed, debris in the intak
This SA supersedes the previously issued bulletin(s) listed below. The changes are noted below in Red. SA-007/25 10/22/25, 06/02/25 and 02/03/25 DESCRIPTION The Mazda DCA-8000 is required for all warranty battery testing. If the Mazda DCA-8000 is not used, incorrect battery testing may result in unnecessary battery replacement. Use the following test procedures in this Service Bulletin to test Mazda vehicle batteries and to generate a Warranty Code. NOTE: A Warranty Code is required for warranty claim submission Battery Identification (Mazda batteries have 2 rating types) 1. JIS (Japanese Indu
NHTSA’s Office of Defects Investigation opens these when complaints point to a possible safety defect. Many end in a recall.
In a letter dated September 14, 2018, Mazda North American Operations (Mazda) notified the National Highway Traffic Safety Administration (NHTSA) of a defect in the front subframe assemblies of model year (MY) 2009 through 2010 Mazda6 vehicles in certain states with high road salt use in winter months (Recall 18V-631). The recall covers approximately 48,814 vehicles that were sold or ever registered in the following states and District of Columbia:Connecticut, Delaware, Illinois, Indiana, Iowa,
Source: NHTSA Office of Defects Investigation public data (complaints, manufacturer communications, investigations), model years 2010 and later. Had a safety problem? Report it to NHTSA.
In complaints filed with NHTSA for model years 2010–2021, owners most often name: unknown or other, air bags, structure. 899 complaints are on record.
No. A complaint is an unverified report from an owner. A technical service bulletin (TSB) is the manufacturer telling dealers how to fix a known issue; it is not a safety recall and is usually covered only under warranty. A recall is a formal safety action, and its repair is free.
File a vehicle safety complaint at NHTSA.gov. NHTSA reads every report, and patterns of complaints are what open defect investigations and, eventually, recalls.
