What Hyundai Sonata Hybrid owners have reported to NHTSA, the service bulletins the manufacturer sent dealers, and any federal defect investigations, by model year. See Hyundai Sonata Hybrid safety recalls or check your VIN.
Complaints owners filed with NHTSA, by the model year of the vehicle. A high count can also mean a popular year, so compare it with how many were sold.
| Year | Complaints | Crashes | Fires | Injured | Deaths | TSBs |
|---|---|---|---|---|---|---|
| 2026 | 3 | 2 | 0 | 2 | 0 | 12 |
| 2025 | 11 | 1 | 0 | 1 | 0 | 18 |
| 2024 | 9 | 0 | 0 | 0 | 0 | 19 |
| 2023 | 15 | 3 | 0 | 2 | 0 | 29 |
| 2022 | 19 | 0 | 0 | 0 | 0 | 46 |
| 2021 | 55 | 1 | 0 | 2 | 0 | 48 |
| 2020 | 16 | 1 | 0 | 1 | 0 | 58 |
| 2019 | 5 | 1 | 0 | 1 | 0 | 80 |
| 2018 | 9 | 0 | 0 | 1 | 0 | 85 |
| 2017 | 80 | 1 | 4 | 0 | 0 | 116 |
| 2016 | 132 | 4 | 3 | 1 | 0 | 130 |
| 2015 | 53 | 4 | 3 | 6 | 0 | 115 |
| 2014 | 27 | 3 | 1 | 3 | 0 | 105 |
| 2013 | 108 | 8 | 4 | 9 | 0 | 107 |
| 2012 | 154 | 2 | 5 | 2 | 0 | 109 |
| 2011 | 96 | 6 | 5 | 5 | 0 | 111 |
The vehicle systems named most often in Hyundai Sonata Hybrid complaints (one complaint can name several).
In the owners’ own words, as filed with NHTSA. Unverified reports; NHTSA removes personal details before publishing.
am writing regarding 43099808 Number with Hyundai My 2019 Sonata hybird se in limp mode with an active flashing P1326 knock sensor code. The dealership is using an automated system denial to try and charge me $2,110 for an EGR valve and air filter.I am officially challenging this diagnostic path. Mathematically and mechanically, an EGR valve or MAF sensor cannot generate the structural rod-bearing acoustic frequency required to trip a manufacturer-specific P1326 engine protection code.Furthermore, the tracy Hyundai certified my vehicle's warranty compliance and replaced my knock sensors under the KSDS campaign only two weeks ago. The fact that the P1326 code flashed again 14 days later prov…
When turning the steering wheel, left or right, there was a distinct âclunkingâ noise, and you could feel it in the steering wheel. When the car was inspected by the Hyundai service department, I was informed that the problem was a part in the steering coupler.
The contact owns a 2015 Hyundai Sonata. The contact stated that while driving approximately 65 MPH, the vehicle failed to properly accelerate. Later, while attempting to accelerate from a yield sign, the vehicle suddenly stalled. The vehicle was later towed to the local dealer to be diagnosed, and it was determined that the engine bearings had failed and the engine needed to be replaced. The manufacturer was notified of the failure. The failure mileage was 97,000.
The vehicle was brought to an authorized Hyundai dealer to have Service Campaign TBH and 94B completed. These campaigns were explicitly designed to prevent known mechanical defects (cracked EHRS assemblies and high-voltage battery errors). The software patches failed to protect the vehicle. The physical hardware has now catastrophically failed exactly as predicted by the campaign, resulting in extreme engine overheating and a physically swollen high-voltage battery pack. Hyundai is refusing to cover the cascading physical damage caused by their own failed campaign remedy, leaving me with an active safety and fire hazard. FUEL/PROPULSION SYSTEM" and explicitly state that the vehicle experienc…
âMy Lincoln Nautilus (~9,180 miles) logged 6 "Powertrain Malfunction / Reduced Power" alerts in the [XXX] telematics system between XXX (XXX at 7:59 PM and 8:16 PM; XXX at 1:07 PM and 1:39 PM; XXX at 11:16 PM; and XXX at 10:56 AM). Out of the 6 logged events, I experienced severe loss of motive power during two of them. On XXX, while driving 70 mph on I-95, the vehicle completely lost all propulsion. Coasting without power, I was unable to pull fully onto the shoulder, leaving the car partially stuck in active traffic and narrowly escaping a high-speed collision. Once stopped, the vehicle failed to recognize that it was in Park, causing the electronic parking brake to lock without releasin…
The contact's sister-in-law owned a 2015 Hyundai Sonata Hybrid. The contact stated that while the vehicle owner was driving 55 MPH, the owner noticed smoke coming from under the hood. The owner parked and exited the vehicle, and while attempting to inspect the vehicle, the owner noticed flames coming from underneath the hood, and the fire extended to the cabin of the vehicle. The Fire Department extinguished the fire and informed the owner that the fire had gone through the firewall and entered the interior of the vehicle. The front seats of the vehicle were completely burned. The vehicle was towed to a local tow yard and was deemed a total loss. The vehicle was under liability insurance. A …
Vehicle Impact:While driving, the vehicle suddenly displayed a "Check Hybrid System" warning on the dashboard and suffered a complete, sudden loss of propulsion while on the road. The vehicle dropped power completely and would not restart, creating an immediate, severe safety hazard to myself and surrounding traffic.Diagnostic & Component Confirmation:The vehicle was towed to a certified Hyundai dealership (Hyundai of Goshen, Repair Order #6080674). Diagnostic testing confirmed trouble codes P0717 (Input Speed Sensor No Signal) and P0A40 (Drive Motor Position Sensor).The dealership's certified technician explicitly documented that they "followed TSB and found input speed sensor valve body ha…
The contact owns a 2017 Hyundai Sonata. The contact stated that the vehicle experienced excessive oil consumption with an abnormal burning odor. The vehicle was taken to a dealer, and an oil consumption test was performed. The contact was informed that the vehicle passed the inspection. While driving later, the vehicle stalled and was taken back to the dealer, where it was determined that the vehicle was consuming an excessive amount of engine oil, and several DTC including the Knock Sensor Detection System (KSDS) were found. The contact stated that while driving or reversing at various speeds, the vehicle shuddered, made abnormal rattling sounds, entered HEV Lock Mode, and the vehicle stall…
Repair instructions and other communications the manufacturer sent dealers about known issues. A TSB is not a recall, and the repair is usually free only while the car is under warranty; ask your dealer for the bulletin number.
The warranty coverage for the clock spring has been extended to 15 years with unlimited mileage from the date of original retail delivery or date of first use. Refer to the warranty and service parts information outlined in this bulletin whenever clock spring replacement is required.
The warranty coverage for the clock spring has been extended to 15 years with unlimited mileage from the date of original retail delivery or date of first use for original & subsequent owners.
The warranty coverage for the clock spring has been extended to 15 years with unlimited mileage from the date of original retail delivery or date of first use. Refer to the warranty and service parts information outlined in this bulletin whenever clock spring replacement is required.
Certain 2026MY Sonata (DN8) and 2026MY Sonata Hybrid (DN8 HEV) vehicles may exhibit a fuel filler door that is difficult to open due to the push-type opener mechanism. Technical Bulletin (TSB) 26-01-057H provides instructions to inspect the fuel filler door push opener and, if necessary, replace the component to restore proper operation.
Certain Sonata (DN8) and Sonata Hybrid (DN8 HEV) vehicles may exhibit a fuel filler door that is difficult to open due to the push-type opener mechanism. This bulletin provides instructions to inspect the fuel filler door push opener and, if necessary, replace the component to restore proper operation.
Certain 2024-2026MY Sonata (DN8) and 2024-2026MY Sonata Hybrid (DN8 HEV) vehicles may exhibit intermittent battery discharge condition due to the air conditioning controller not fully powering down after the vehicle is turned off and parked. Technical Service Bulletins (TSB) 26-01-051H & 26-01-052H provide the procedure to update the ATCU (Air Temperature Control Unit) software; the revised logic improves controller shutdown to prevent battery drain and corrects a condition where the HVAC control display may appear blank when climate remote start is activated via Bluelink. Over-the-Air (OTA):
Certain Sonata Hybrid (DN8 HEV) vehicles may exhibit intermittent battery discharge conditions due to the air conditioning controller not fully powering down after the vehicle is turned off and parked. This bulletin provides the procedure to update the Air Temperature Control Unit (ATCU) software; the revised logic improves controller shutdown to prevent battery drain and corrects a condition where the HVAC control display may appear blank when climate remote start is activated via Bluelink.
Some Sonata Hybrid (DN8 HEV) vehicles may display a Check Engine light and store one or more of the DTCs listed below due to an abnormal air-fuel ratio in a specific cylinder. This bulletin provides instructions to update the Engine Control Module (ECM) to resolve the air-fuel ratio logic.
This bulletin provides information related to the navigation and head unit software changes introduced in the 2026 1st Navigation Map and Software Update. The changes may vary depending on vehicle type, model, and navigation system. Refer to the 2026 1st Navigation Map and Software Update Key Improvements and Additional Improvements tables in this TSB for a list of specific changes. The software can be downloaded via Navigation Updater (NAU) and updated by USB.
The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driverâs-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the vehicle manufacturers and have primarily been found in vehicles that previously experienced a crash and underwent airbag replacement using non-genuine parts. These dangerous inflators have ruptured during deployment, posing a serious risk of injury or death due to metal fragments entering the vehicle
The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driverâside airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. vehicles following prior crashes, theft, or nonâcertified airbag replacements. These inflators are not approved for use, may rupture during deployment, and have caused serious injuries and fatalities. Please see attached announcement, provided by NHTSA, for more details.
Some vehicles may exhibit a loss of connectivity or interruptions in the middle of using Bluelink functions. This may be due to an occasional disconnection on Verizonâs communication network. Follow the procedures in this bulletin to verify Bluelink Data Communication Unit (DCU) network connection and if needed, reset the DCU in Dealer Mode to resolve the connection.
NHTSA’s Office of Defects Investigation opens these when complaints point to a possible safety defect. Many end in a recall.
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando.
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-spe
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug
On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles. During the PE investigations, Hyundai and Kia issued several recalls to address vehicle fires, including those due to engine failures involving various engine types. The remedies for the engine fail
The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicles may be equipped with an airbag control unit (ACU) for the supplemental restraint system (SRS) Ele
During this Preliminary Evaluation (PE), the Office of Defects Investigation (ODI) assessed the scope, frequency and potential safety-related consequences of non-crash vehicle fires caused by both engine failures and failures of other vehicle systems/components in model year (MY) 2011-2014 Hyundai Sonata and Santa Fe vehicles equipped with Theta II and Lambda II engines (approximately 1.3 million vehicles). ODI also reviewed field data of other Hyundai vehicles equipped with Theta II, Gamma, Nu
In a letter dated June 11, 2018, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a safety defect investigation into non-collision related fires on model year (MY) 2011-2014 Kia Optima and Sorento, and Hyundai Sonata and Santa Fe vehicles. In a letter dated July 24, 2018, CAS requested that MY 2010-2015 Kia Soul vehicles be added to the petition. CAS stated that there is a higher number of complaints to NHTSA regarding non-crash f
The Office of Defects Investigation (ODI) opened PE18-003 on 3/16/18 to investigate incidents involving crashes, resulting in significant collision related damage, where the frontal airbags failed to deploy. ODI reviewed complaint data, available design, test, and field data on the model year (MY) 2011 Hyundai Sonata, MY 2012-2013 Kia Forte and Forte Koup vehicles. ODI also evaluated data from the automotive air bag system supplier, ZF-TRW (ZF), to review vehicles that may contain the same air b
Source: NHTSA Office of Defects Investigation public data (complaints, manufacturer communications, investigations), model years 2010 and later. Had a safety problem? Report it to NHTSA.
In complaints filed with NHTSA for model years 2011–2026, owners most often name: engine, electrical system, power train. 792 complaints are on record.
No. A complaint is an unverified report from an owner. A technical service bulletin (TSB) is the manufacturer telling dealers how to fix a known issue; it is not a safety recall and is usually covered only under warranty. A recall is a formal safety action, and its repair is free.
File a vehicle safety complaint at NHTSA.gov. NHTSA reads every report, and patterns of complaints are what open defect investigations and, eventually, recalls.
