Every recall we track for Rivian Automotive, LLC — 23 in all — plus the complaints and injury reports the public filed about them.
Rivian is recalling certain 2025 R1T vehicles with faulty turn signals that could increase crash risk. Owners will receive free inspections and replacements by September 2026.
Rivian is recalling 2025 R1S vehicles with headlight failure in cold weather, risking reduced visibility and crashes. Owners must contact Rivian for free headlight control module replacement.
Rivian is recalling 2022 R1S vehicles with improperly secured side curtain air bags that may not deploy correctly during crashes, risking injury. Owners must have air bags repaired by March 15, 2023.
Rivian is recalling certain 2022-2023 R1S vehicles due to reverse lights that may not be visible from some angles, potentially causing crashes. Owners must contact Rivian for free repair or replacement.
Rivian is recalling 2022 R1T vehicles with faulty seat belt sensors that may prevent airbag deployment during crashes. Owners must contact Rivian for free repairs by April 5, 2023.
Rivian is recalling 2022 R1T vehicles with front passenger seats that may deploy air bags during crashes if a child is present, risking injury. Owners must have seats replaced free by Rivian service centers.
Rivian is recalling 2022 R1T vehicles with improperly secured seat belt anchors that may not restrain occupants during crashes, increasing injury risk. Owners must have seat belt assemblies inspected by Rivian.
Rivian is recalling 2022 R1T vehicles with a loose steering knuckle fastener that could cause loss of vehicle control and crash risk. Owners must have their vehicle inspected by dealers.
Complaints and injury reports the public filed with federal agencies, linked to Rivian Automotive, LLC’s recalls — unedited excerpts.
SYSTEMS AFFECTED: Electrical System (12V Power Supply / Low-Voltage), Climate Control (HVAC System / Thermal Management), Towing / Recovery DESCRIPTION OF SAFETY HAZARD & DEFECT: My 2022 Rivian R1T experienced a sudden, complete electrical failure due to a def…
This vehicle has experienced two separate failures of the high-voltage (HV) battery pack, each resulting in a different drive unit being damaged and total loss of electrical systems while driving. First incident (July 28, 2025): While driving, all warning ligh…
The R1T has four cameras to assist the driver and provide warnings for lane changes, etc. The cameras are routinely failing while I am driving the vehicle. This started after an OTA software update. A software reset will turn the cameras back on, though the…
Vehicle gave a warning to service the electrical system and then shut down preventing any operation. Luckily I was in a parking lot and not on a roadway impeding traffic or jeopardizing safety while driving. Could smell burnt electrical from within cabin. Had…
I was driving to a restaurant and out of nowhere started hearing this metal-on-metal sound 1/4 mile before I got there. I pulled into the parking lot and it kept getting worse, so I called Rivian to tow the car. They confirmed it was a hub and shaft bolt that …
Rear Suspension Dampers leaking prematurely which could cause unsafe driving issues.
This complaint is associated with Complaint #11717398. My 3rd windshield has cracked after a tiny 1/8" impact point. The result was spidering all the way around the middle sensor housing area and propagating 6" down. It also spidered to the top of the windshie…
12 volt battery was replaced under warranty on date 07/08/2024 at miles 14059. Again, 12 volt battery needs to be replaced at 29343 miles as of today's date 04/12/2026. This is highly unusual. Please look into it. Prakashkumar Patel, MD
