What Peterbilt 587 owners have reported to NHTSA, the service bulletins the manufacturer sent dealers, and any federal defect investigations, by model year. See Peterbilt 587 safety recalls or check your VIN.
Complaints owners filed with NHTSA, by the model year of the vehicle. A high count can also mean a popular year, so compare it with how many were sold.
| Year | Complaints | Crashes | Fires | Injured | Deaths | TSBs |
|---|---|---|---|---|---|---|
| 2021 | 0 | 0 | 0 | 0 | 0 | 18 |
| 2020 | 0 | 0 | 0 | 0 | 0 | 23 |
| 2019 | 0 | 0 | 0 | 0 | 0 | 32 |
| 2018 | 0 | 0 | 0 | 0 | 0 | 37 |
| 2017 | 1 | 0 | 0 | 0 | 0 | 40 |
| 2016 | 0 | 0 | 0 | 0 | 0 | 35 |
| 2015 | 0 | 0 | 0 | 0 | 0 | 32 |
| 2014 | 0 | 0 | 0 | 0 | 0 | 31 |
| 2013 | 2 | 0 | 0 | 0 | 0 | 28 |
| 2012 | 3 | 0 | 2 | 0 | 0 | 23 |
| 2011 | 0 | 0 | 0 | 0 | 0 | 26 |
| 2010 | 0 | 0 | 0 | 0 | 0 | 22 |
The vehicle systems named most often in Peterbilt 587 complaints (one complaint can name several).
In the owners’ own words, as filed with NHTSA. Unverified reports; NHTSA removes personal details before publishing.
The contact owns a 2012 Peterbilt 587. The contact stated while driving 65 MPH, the vehicle stalled. The contact was unaware of a warning light being illuminated. The contact pulled over to the side of the road where the vehicle failed to restart. The vehicle was towed to West Truck Services Center, where it was diagnosed and determined that the fuel pump had failed. The vehicle was then towed to the dealer, where it was diagnosed that the fuel pump plungers had fractured and intruded the engine. Additionally, the dealer informed the contact that there were metal shavings inside the oil filter. The dealer determined that the fuel pump and engine rod bearings needed to be replaced. The vehicl…
The contact owns a 2013 Peterbilt 587. The contact stated that the odometer became inoperable. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 60,334. The VIN was not available.
THE CLIMATE CONTROL MODULE FOR THE CAB, AND THE BUNK KEEP SHORTING OUT. THE FAN SPEED CONTROL LITERALLY MELTS. THE CONTROL STICKS THEN STARTS SMOKING. I HAVE HAD PETERBILT REPLACE IT, BUT IT KEEPS GOING OUT. I'M AFRAID IT'S GOING TO BURN THE TRUCK UP WHILE I'M ASLEEP.
65 MPH COMPLETE LOSS OF ELECTRICAL POWER AND ENGINE POWER. IDENTIFIED JUNCTION BOX AS THE PROBLEM.
2012 PETERBILT TRACTOR. CONSUMER WRITES IN REGARDS TO POTENTIAL FIRE DEFECT. *SMD THE CONSUMER STATED HE RECENTLY INVESTIGATED THE CAUSE OF A FIRE IN THE TRACTOR AND DETERMINED THE CAUSE TO BE RELATED TO A POTENTIAL DEFECT IN THE MANNER IN WHICH THE BATTERY CABLES WERE SUPPORTED. THE BATTERY CABLES PASSED FROM THE BATTERY BOX ON THE DRIVER SIDE OF THE TRACTOR, AT A POSITION BEHIND THE CAB, TO THE ENGINE COMPARTMENT. AT THE LOCATION WHERE THE BATTERY CABLES PASSED THE ELECTRONIC CLUTCH ACTUATOR, THEY WERE HELD IN PLACE BY A PLASTIC TIE. DUE TO DRIVE TRAIN VIBRATION AND MOVEMENT, THE PLASTIC TIE USED TO SECURE THE BATTERY CABLES TO THE CLUTCH ACTUATOR SHIELD WERE PRONE TO FAILURE. THE PLASTI…
TL* THE CONTACT OWNS A 2012 PETERBILT 587. THE CONTACT STATED THAT HE NOTICED SMOKE COMING FROM THE UNDERCARRIAGE. THE CONTACT EXITED THE VEHICLE AND DISCOVERED THERE WAS A FIRE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE WITH A FIRE EXTINGUISHER. AFTER FURTHER INSPECTION, IT WAS DETERMINED THAT THE BATTERY CABLE HAD IGNITED. THE CABLES WERE ATTACHED TO THE ELECTRONIC CLUTCH ACTUATOR, WHICH HAD A PLASTIC COVER. THE PLASTIC TIE FRACTURED AND CAUSED THE BATTERY CABLES TO FAIL, ENERGIZING THE TRANSMISSION AND ENGINE BLOCK. THE HIGH HEAT CAUSED IT TO BECOME COMBUSTIBLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN BECAUSE OF THE FIRE DAMAGE. *TR UPDATED 7/2/13 *CN THE CO…
Repair instructions and other communications the manufacturer sent dealers about known issues. A TSB is not a recall, and the repair is usually free only while the car is under warranty; ask your dealer for the bulletin number.
"Kenworth: Dealers should check the chassis list and SIR weekly for VIN changes. 2 chassis added to the chassis list. Peterbilt: Dealers should check the chassis list and SIR weekly for VIN changes. 10 chassis added to the chassis list."
This recently published bulletin has been updated to include inspection procedures to assess if a hood is repairable.
Info Only Unnecessary starter replacements can result from customer complaints regarding engine starting issues. A new Starter Troubleshooting Guide has been created to provide a comprehensive list of starting system checks, which should reduce unnecessary starter replacements and associated warranty claims. Engine starting system warranty claims now require a completed Starter Checklist, a Battery Pack Midtronics Report, and a Cable Drop Midtronics Report. Claims filed without these documents may be denied.
7/700 Service Agreement - Letter Only.
Emissions Recall Certain vehicles with PACCAR MX-11 and MX-13 EMY2016 engines with less than 300,000 miles (482,803 km) have been shown, in testing, to exceed regulatory limits for NOx and N2O emissions. This bulletin now applies to both Canadian and U.S. registered vehicles. Software is now available to remedy this emissions non-compliance.
An engine software defect exists in certain vehicles equipped with EMY17 MX-13 and MX-11 engines that pertains to timer action and count calibrations for a time-based diagnostic. This diagnostic action checks fuel pressure and has no negative impact on tailpipe emissions. This soft ware may incorrectly set DTC âÃÂàP1092.
Fix As Fail â Chassis that were manufactured with certain battery cable routing brackets may experience rubbing or chafing of the battery cables.
This campaign is the final opportunity to replace the oil filter screw cap to reduce occurrences of broken bypass valve tabs. Broken oil valve tabs can cause oil flow obstruction to critical engine parts, resulting in serious engine damage. Customers that do not receive this repair may be responsible for progressive engine damage caused by broken oil bypass valve tabs.
Info Only - PACCAR is introducing Over-the-Air (OTA) software updates for engine MY17 and newer chassis equipped with Cummins X15, X12, ISX12, ISX12N, L9N, PX-7, and PX-9 engines The technology will leverage the existing Remote Diagnostic cs hardware to deliver secure software updates remotely. This will reduce downtime and save on maintenance costs for eligible vehicles.
The service information for Bendix Air Dryer maintenance is being updated to include new procedures.
Information Only â New Level 1 required tools are available to support MY21B MX engines.
Due to major data carriers phasing out 3G networks, chassis currently utilizing first generation Peoplenet Mobile Gateway (PMG001) will experience severe 3G service degradation as early as January of 2022. Chassis currently utilizing 3G antennas as a primary antenna may experience this degradation.
NHTSA’s Office of Defects Investigation opens these when complaints point to a possible safety defect. Many end in a recall.
The Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE21-015) based on one Vehicle Owner Questionnaire (VOQ) and supporting fleet reports. The reports indicated that the subject quarter fenders were prone to cracking and/or separation.After a comprehensive review of the data related to the quarter fender failures on the subject vehicles, ODI did not identify the existence of a safety-related defect trend. Quarter fender failures resulted in a warranty claim rate less th
Source: NHTSA Office of Defects Investigation public data (complaints, manufacturer communications, investigations), model years 2010 and later. Had a safety problem? Report it to NHTSA.
In complaints filed with NHTSA for model years 2010–2021, owners most often name: electrical system, engine, exterior lighting. 6 complaints are on record.
No. A complaint is an unverified report from an owner. A technical service bulletin (TSB) is the manufacturer telling dealers how to fix a known issue; it is not a safety recall and is usually covered only under warranty. A recall is a formal safety action, and its repair is free.
File a vehicle safety complaint at NHTSA.gov. NHTSA reads every report, and patterns of complaints are what open defect investigations and, eventually, recalls.