What Chevrolet Aveo owners have reported to NHTSA, the service bulletins the manufacturer sent dealers, and any federal defect investigations, by model year. See Chevrolet Aveo safety recalls or check your VIN.
Complaints owners filed with NHTSA, by the model year of the vehicle. A high count can also mean a popular year, so compare it with how many were sold.
| Year | Complaints | Crashes | Fires | Injured | Deaths | TSBs |
|---|---|---|---|---|---|---|
| 2018 | 0 | 0 | 0 | 0 | 0 | 266 |
| 2017 | 0 | 0 | 0 | 0 | 0 | 286 |
| 2016 | 0 | 0 | 0 | 0 | 0 | 287 |
| 2015 | 0 | 0 | 0 | 0 | 0 | 296 |
| 2014 | 0 | 0 | 0 | 0 | 0 | 278 |
| 2013 | 0 | 0 | 0 | 0 | 0 | 378 |
| 2012 | 1 | 0 | 0 | 0 | 0 | 358 |
| 2011 | 77 | 10 | 1 | 4 | 1 | 1,078 |
| 2010 | 66 | 8 | 0 | 8 | 0 | 1,055 |
The vehicle systems named most often in Chevrolet Aveo complaints (one complaint can name several).
In the owners’ own words, as filed with NHTSA. Unverified reports; NHTSA removes personal details before publishing.
The contact owns a 2010 Chevrolet Aveo. The contact stated that while driving at an undisclosed speed and attempting to stop the vehicle, the vehicle was bouncing. The contact also stated the key had gotten stuck inside the ignition switch. The contact called the local dealer and was informed that the failure could be attributed to driver's error. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 5,000.
TL* THE CONTACT OWNS A 2010 CHEVROLET AVEO. THE CONTACT STATED WHILE DRIVING 40 MPH, THE BRAKE PEDAL WAS DEPRESSED AND THE A-ARM CONNECTING THE STEERING TO THE TIRES UNDERNEATH THE VEHICLE COLLAPSED. THE CONTACT PULLED OVER, WAITED FOR A FEW MINUTES, AND THEN SLOWLY DROVE THE VEHICLE BACK TO THE RESIDENCE. THE CONTACT STATED THERE WAS NO WARNING LIGHT ILLUMINATED. THE CONTACT REACHED OUT TO LBSI AUTOMOTIVE LLC (109 PITTSBURGH RD, UNIONTOWN, PA 15401, (724) 437-5274) BUT GOT NO RESPONSE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 143,943.
PRIME WALL TIRES 185/60/R14, PIMEWALL TIRES PS830 185/60/R14 ARE SEPARATING FROM THE SEAM
TL* THE CONTACT OWNS A 2010 CHEVROLET AVEO. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED AN INTERMITTENT STARTING FAILURE WITHOUT WARNING. THE CONTACT WAS INFORMED OF AN UNKNOWN RECALL ON THE VEHICLE WHILE THE EMISSIONS TEST WAS BEING PERFORMED. THE VEHICLE WAS TAKEN TO MARXEN CHEVROLET CADILLAC (1118 W HISTORIC ROUTE 66, FLAGSTAFF, AZ 86001) WHERE THE CONTACT WAS INFORMED THAT THE VIN WAS NOT SUBJECTED TO A RECALL. THE MANUFACTURER WAS INFORMED OF THE FAILURE AND CONFIRMED THAT THE VIN WAS NOT SUBJECTED TO A RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 66,000.
THE PASSENGER SEAT SENSOR IS DEFECTIVE CAUSING THE PASSENGER AIR BAG TO TURN OFF MAKING IT DANGEROUS FOR A PASSENGER IN CASE OF ACCIDENT
I HAVE BEEN TO THE SHOP SO MANY TIMES SINCE I BOUGHT THIS CAR. THE FIRST TIME OUT OF NOWHERE IT STARTED SMOKING WHITE SMOKE AND OVERHEATED THE ENGINE AND COME TO FIND OUT THE TUBING IN THE CAR HAD EXPLODED. THEN GOT EVERYTHING FIXED AND NOW STILL HAVING THE SAME PROBLEM WITH OVERHEATING AND WHITE SMOKE BUT NOW A BURNING SMELL. IT'S SOMETHING NEW EVERY TIME. I FOUND THIS RESPONSE O. YOUR WEBSITE WITH ANOTHER PERSON WHO HAS THIS CAR AND THIS HAPPENED TO MINE AS WELL: ' HOSES TO MY COOLING SYSTEM ALL BUSTED ONE AFTER ANOTHER WITH IN 5 DAY WE COULD SEE THE WEEK SPOT IN THE HOSE AFTER THY BUSTED,HAD THE THERMOSTAT CHANGED , IT ALSO BLOW MY HEAD GASKET' THIS IS ALSO HAPPENED AND I BARELY DRIVE IT…
KEY GETS LOCKED IN IGNITION. IT WONT TURN OR IF IT TURNS IT DOES NOT COME OUT.
ARRIVED AT HOME PUT MY CAR IN PARK AND MY KEY WAS STUCK IN THE IGNITION AND UNABLE TO SHUT MY CAR OFF. HAD TO PULL FUSE TO THE COMPUTER AND DISCONNECT NEGATIVE SIDE OF BATTERY. TOOK IT TO A SHOP THEY ADVISED NO COMMUNICATION WITH SHIFTER. SHOP DRILLED OUT MY OLD IGNITION LOCK CYLINDER AND REPLACED WITH A NEW KEY LOCK CYLINDER. SEEMS TO BE WORKING AS OF NOW AFTER A $518.74 BILL.
Repair instructions and other communications the manufacturer sent dealers about known issues. A TSB is not a recall, and the repair is usually free only while the car is under warranty; ask your dealer for the bulletin number.
This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.
This preliminary information communicates information about how to determine if a wheel and tires size change is available.
This Preliminary information communicates the steps on how to save a GDS2 Session Log and upload to a Technical Assistance Case in CX Connect.
This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.
This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.
This Preliminary Information communication provides information to the technician about vehicles that have had multiple repair attempts that are being performed on customerâs vehicles that exhibit vibration conditions without utilizing the support of General Motors Technical Assistance Center. If valid vibration frequency or Road Force Variation data has been collected and a repair attempt does not correct the customer complaint, contact General Motors Technical Assistance Center for further support. For any vehicles that remains unrepaired after being at the dealer for three days or more an
New Vehicle Monitoring Programs Section in IVH
This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.
This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3060, B3935, C0750, C0755, C0760, C0765, and/or C0775.
This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.
This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.
This service bulletin provides information on Tire Sidewall Irregularities.
Source: NHTSA Office of Defects Investigation public data (complaints, manufacturer communications, investigations), model years 2010 and later. Had a safety problem? Report it to NHTSA.
In complaints filed with NHTSA for model years 2010–2018, owners most often name: engine, electrical system, power train. 144 complaints are on record.
No. A complaint is an unverified report from an owner. A technical service bulletin (TSB) is the manufacturer telling dealers how to fix a known issue; it is not a safety recall and is usually covered only under warranty. A recall is a formal safety action, and its repair is free.
File a vehicle safety complaint at NHTSA.gov. NHTSA reads every report, and patterns of complaints are what open defect investigations and, eventually, recalls.
